Free on-site gate assessment - hinges, posts, and your LiftMaster or Nice gate operator checked before anything is quoted
The assessment is free and the quote is the invoice.
Before
After
Before
After
Before
AfterFAAC Keypad & Intercom Repair: The Gardena Owner’s Guide
FAAC keypad and intercom repair in Gardena typically runs $275 to $520 installed, and we stock the most common FAAC-compatible keypads and intercom modules on the truck, so most jobs are done the same day we show up. The way homeowners usually find us is simple: the keypad stops taking a code, or the intercom still rings but nobody can hear the “come in” through the call box. You press the buttons, the unit clicks or stays silent, and the gate does nothing. That is almost always the keypad membrane or the intercom board, not the gate motor itself.
Which FAAC Models This Applies To
We work on FAAC keypads and intercoms across the 400, 412, 415, S418, and C720 series, plus the older DigiKey and DKS-compatible wall stations still running on plenty of Gardena driveway gates. The complication with FAAC specifically is wiring: some FAAC keypads run on a four-wire bus, others need a six-wire with a separate audio path for the intercom. If a handyman wires a four-wire keypad into a six-wire panel, the gate will open but the intercom audio gets dead air. We check the terminal labels before anything else. As for OEM versus aftermarket, FAAC’s original keypads are well made, but the rubber membrane under the buttons hardens in California sun within six to eight years. We stock both OEM and quality aftermarket units, and for a keypad that sits in direct western exposure, a metal-face aftermarket often outlasts the original. We are an independent service provider, not affiliated with FAAC, but we install their equipment daily.
Signs Your FAAC Keypad & Intercom Repair Is Failing
- Buttons need a hard press, then stop responding. The carbon pill under the membrane wears flat. The fix is a new membrane or a complete keypad, not more elbow grease.
- Gate opens with the remote but not the keypad. That points to the keypad’s output circuit or a severed wire at the hinge, usually where the wire flexes every time the gate swings. We find this constantly on older Gardena properties where the gate has been swinging for twenty years.
- Intercom rings but the audio is one-way or full of static. The intercom board’s amplifier section is fading, or the microphone at the street station has filled with dust and oxidation. Sometimes a cleaning fixes it, often the board needs replacement.
- Keypad lights up but the gate does not move. The keypad is sending a signal that never reaches the control board. This is the wiring or a relay, and it is a quick diagnostic with a meter.
- Codes work intermittently, usually worse in cold or damp weather. The keypad’s internal contacts are corroded or a solder joint has cracked. Gardner’s marine layer is gentle on people, hard on exposed electronics.
Replacement Cost & What’s Included
In Gardena, a FAAC-compatible keypad replacement installed runs between $275 and $420 depending on whether it is a simple four-wire swap or a six-wire with intercom integration. A full keypad and intercom module replacement together lands in the $420 to $520 range. The parts themselves are the smaller half; the labor covers the wiring check, terminal cleanup, and testing the unit through at least ten open-and-close cycles before we call it done. Every replacement includes our written 90-Day Done Right Promise. The price is quoted and agreed before any work starts, so the number on the invoice matches the number you heard. That is how we have worked since Victor Salinas started this company, and we are not changing now.
DIY or Call Us?
What you can safely do yourself: check that the keypad’s wiring at the gate has not been chewed by a gardener’s edger, and confirm the gate’s own breaker is on. That is about it. A FAAC keypad is low-voltage, so it will not throw you across the driveway, but the wiring is easy to cross and the control board is expensive to replace when it is done wrong. We get calls after DIY attempts where a homeowner swapped two wires, blew the relay on the gate board, and turned a $300 keypad repair into an $850 control board replacement. If the keypad is dead, call us at (916) 398-2696. We will tell you over the phone whether it sounds like a keypad, a wire, or a board.
FAQs
A FAAC keypad and intercom typically lasts six to ten years in Gardena’s climate, with the keypad membrane failing first because of sun exposure and the intercom board following a year or two behind. If your keypad sits on a west-facing wall in direct afternoon sun, the lifespan lands near the bottom of that range. Call (916) 398-2696 and we can tell you if yours is worth repairing or replacing.
Yes, if the issue is the membrane or a cracked wiring connection. If the circuit board itself is failing, replacement is the honest fix and usually costs only slightly more than a board-level repair would. We will not sell a repair that will fail again in six months.
Most FAAC keypad and intercom replacements take between 45 minutes and two hours, depending on the wiring and whether we need to replace the intercom module as well. We arrive with the common parts on the truck, so there is rarely a second visit.
We stock the most common FAAC-compatible keypads, membranes, and intercom modules on our trucks, which covers most Gardena service calls. If you have an older or unusual FAAC model, we can order the correct part and have it in within a few days. Call (916) 398-2696 with your model number and we can tell you straight away.
Call Ironworks Gate Co. for FAAC Keypad & Intercom Repair in Gardena
If your FAAC keypad is dead or the intercom is half-working, call (916) 398-2696. A live person answers, 24 hours a day, every day. We will give you a straight assessment over the phone, then show up on time, fix the keypad or intercom correctly, and stand behind the job with our written 90-Day Done Right Promise. Free estimates, upfront pricing, and no surprises on the bill, ever. We are the gate specialists Gardena has trusted for over 42 years, and we plan to be here for the next forty.
Written by Victor Salinas, Owner, Ironworks Gate Co. at Ironworks Gate Co., serving Gardena and nearby areas.